Product ID:MIL-C-85285, 10056 CAMF. GREEN POLYURETHANE
MSDS Date:11/10/1986
FSC:8010
NIIN:01-265-9141
Kit Part:Y
MSDS Number: BWFCT

SEAGRAVE COATINGS CORP

320 PATERSON PLANK ROAD
CARLSTADT, NJ 07072
US

Emergency Phone: 201-933-1000

Info Phone: 201-933-1000

Cage: 53762

SEAGRAVE COATINGS CORP

CARLSTADT, NJ 07072 US

Telephone: 201-933-1000

Cage: 53762

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 29.5% %

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL;9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: 17.5%

OSHA PEL NOT ESTABLISHED.

ACGIH TLV: NOT ESTABLISHED.

SILICA GEL

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 23% %

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LEAD CHROMATE

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 10.4% %

OSHA PEL 0.1 MG(CRO3)/M3

ACGIH TLV: 0.012MG(CR)/M3,A2;94

POLYESTER RESIN NONHAZARDOUS

Fraction By Weight: 19.6% %

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION TO SKIN, EYES AND
RESPIRATORY TRACT. WATERING OF EYES, DRYNESS OF THROAT, COUGHING,
HEADACHE, TIGHTNESS IN CHEST OR BURNING SENSATION. RESPIRATORY
SENSITIVITY RESULTS IN ASTHMA-LI KE SYMPTOMS. SKIN SENSITIVITY
RESULTS IN ALLERGIC DERMATITIS CAUSING RASH, ITCHING, HIVES AND
SWELLING OF EXTREMITIES.
Explanation of Carcinogenicity:CONTAINS LEAD CHROMATE.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, DERMATITIS,
UPPER RESPIRATORY TRACT IRRITATION, WATERING OF EYES, DRYNESS OF
THROAT, COUGHING, HEADACHE, TIGHTNESS IN CHEST, BURNING SENSATION,
RASH, ITCHING, HIVES, S WELLING OF EXTREMITIES, PALOR, NAUSEA,
DIZZINESS, WEAKNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Lower Limits:1.24 %
Upper Limits:12.7 %
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DO NOT USE DIRECT STREAM OF WATER ON
FIRE. TOXIC GASES ARE RELEASED DURING COMBUSTION. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAME.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. EVACUATE AREA.
WEAR PROPER PERSONAL PROTECTIVE EQUIPMENT. CONTAIN SPILL. STOP LEAK
IF CAN DO SO WITHOUT RISK. ABSORB LIQUID WITH SUITABLE ABSORBENT
MATERIAL. PLACE IN SE ALED METAL CONTAINERS USING NON-SPARKING
TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN RED LABEL AREA IN ORIGINAL
CONTAINERS. GROUND ALL EQUIPMENT AND CONTAINERS. STORE BELOW 122F.
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.

Respiratory Protection:APPROVED CHEMICAL FILTERS DESIGNED TO REMOVE A
COMBINATION OF PARTICLES/VAPORS, IN CONFINED AREAS USE APPROVED AIR
LINE TYPE RESPIRATORS OR HOODS.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
IF SKIN CONTACT IS LIKELY, USE A PROTECTIVE SKIN CREAM.

HCC:F2
Boiling Pt:B.P. Text:175-302F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:> 1
Spec Gravity:1.258
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, MILD ODOR

Stability Indicator/Materials to Avoid:YES
DO NOT COMBINE WITH PHOSPHOROUS CONTAINING MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAME, TEMPERATURES ABOVE 122F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
LEAD/CHROMATE FUME

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.